Poulan 188781 Manual de usuario

OWNER'S MANUALMODEL:PD22H42STALAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION WARNING:Read this Owner's Man u al and foll

10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to

11OPERATIONThe operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safe

12OPERATIONTO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope.• Choose th

13OPERATIONTO START ENGINE (See Fig. 5)When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking t

14FIG. 10 MOWING TIPS• Mower should be properly leveled for best mowing per-formance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustmen

15MULCHING MOWING TIPSIMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE.• The spe cia

16MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil

17MAINTENANCEBLADE REMOVAL (See Fig. 12)• Raise mower to highest position to allow access to blades.• Remove blade bolt, lock washer and fl at

18MAINTENANCEV-BELTSCheck V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not ad just able. Re

19MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

2DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible.• Do not mow near drop-offs, ditch

20SERVICE AND ADJUSTMENTSWARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST -MENTS• Depress clutch/brake pedal fully and set

21SERVICE AND ADJUSTMENTSNUT "E""D""D"MANDRELFIG. 20NUT "F"FRONT LINKSFIG. 21FRONT-TO-BACK ADJUSTMENT (See Fig

22SERVICE AND ADJUSTMENTSFIG. 22TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 22)The mower blade drive belt may be replaced without tools. Park the tra

23SERVICE AND ADJUSTMENTSTO REMOVE WHEEL FOR REPAIRS (See Fig. 26)• Block up axle securely.• Remove axle cover, retaining ring and washers

24SERVICE AND ADJUSTMENTSTO REPLACE HEADLIGHT BULB• Raise hood.• Pull bulb holder out of the hole in the backside of the grill.• Replace

25ENGINETO AD JUST THROTTLE CON TROL CABLE (See Fig. 30)The throttle control has been preset at the factory and ad just ment should not be necessary.

26STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

27TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

28TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presence control system. 1. Check wiring, switches

29BATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITHEADLIGHTSREMOVABLECONNECTIONSBLACKBLACKBLACKWHITEWHITEWHITEREDBLACKORANGEBLACKBROWNBLACKBLACKBLA

3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl

30TRACTOR - - MODEL NUMBER PD22H42STA ELECTRICAL 2829262442432727254127274033301212111082127D.C. AMPERES451622215216

31TRACTOR - - MODEL NUMBER PD22H42STA ELECTRICAL KEY PARTNO. NO. DESCRIPTION1 144927 Battery 2 74

32TRACTOR - - MODEL NUMBER PD22H42STA CHASSIS 103020931192082092095520726144261020914220914258208132081164143601453737181414383816639209220674159

33TRACTOR - - MODEL NUMBER PD22H42STA CHASSIS KEY PART NO. NO. DESCRIPTION1 174619 Chassis 2

34TRACTOR - - MODEL NUMBER PD22H42STA DRIVE 6629281121314413839571207475787677125192425335343736356236646559565563776122272661131851518685523032323

35TRACTOR - - MODEL NUMBER PD22H42STA DRIVE KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO. DESCRIPTION1

36TRACTOR - - MODEL NUMBER PD22H42STA STEERING ASSEMBLY 5534395438104011868746468687298871174391214142373637381239445154686767671365681515152929

37TRACTOR - - MODEL NUMBER PD22H42STA STEERING ASSEMBLY KEY PARTNO. NO. DESCRIPTION1 184704X428 Wheel Steering 2

38TRACTOR - - MODEL NUMBER PD22H42STA SEAT ASSEMBLY 1 188720 Seat2 140551 Bracket Pivot Seat 8 7203 71

39TRACTOR - - MODEL NUMBER PD22H42STA DECALS NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mmKEY PART

4GASOLINE CAPACITY 4.0 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 30 (above 32°F) SAE 5W-30

40TRACTOR - - MODEL NUMBER PD22H42STA ENGINE 21OPTIONAL EQUIPMENTSpark Arrester2910657213262548323133373317173812345143841112engine-bs intek-twin_3

41TRACTOR - - MODEL NUMBER PD22H42STA ENGINE KEY PART NO. NO. DESCRIPTIONNOTE: All component dimensions given in

42151413111098166830313233146148145150451441471471421491425452535556341464421242526272282923212121181820248591943562140143364037401591403718442_deck_m

43TRACTOR - - MODEL NUMBER PD22H42STA MOWER DECK KEY PART NO. NO. DESCRIPTIONKEY PART NO. NO.

44TRACTOR - - MODEL NUMBER PD22H42STA MOWER LIFT 36152016171820201520456231654783741403812113132313219191313131323242527282930502649lift-rh.1pc.st

45TRACTOR - - MODEL NUMBER PD22H42STA MOWER LIFT 1 159461 Wire Asm Inner/Sprg W/plunger 2 159476 Shaft Asm Lif

46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

Your POULAN PRO product has been expertly en gi neered and carefully manu fac tured to rigid quality stan dards. As with all mechanical products

5UNASSEMBLED PARTS(1) Large Flat WasherSteering Wheel InsertSteering SleeveSteering Wheel(1) Knob(1) Washer 17/32 x 1-3/16 x 12 GaugeSeat(2) KeysSlop

602601ASSEMBLYTOOLS REQUIRED FOR ASSEMBLYA socket wrench set will make assembly easier. Stan dard wrench sizes are listed.Utility knife Pliers(1

7ASSEMBLYFIG. 3SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATHOW TO SET UP YOUR TRACTORINSTALL SEAT (See Fig. 3)Adjust seat before tightening adj

8INSTALL MULCHER PLATE (See Figs. 4)• Install two latch hooks to mulcher plate using screw, washer, lock washer, and weld nut as shown. NOTE: Pr

9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDS